Replacing the air filter Mazda 6 (GJ)

Parts and consumables:

• rags 
• chocks
• Water container
• Air filter Mazda PE07-13-3A0A

Mazda 6 filter change interval

According to routine maintenance, the Mazda 6 air filter is replaced every 30 thousand km. run. Even with the highest quality filter element, particles of debris and dust inevitably enter the combustion chamber and reduce ignition efficiency.

If the car is mainly operated on rough terrain with high dust content, then the interval is reduced by 3 times (every 10 thousand km.). The location of the air intake also affects the duration of operation.

Reasons to replace the Mazda 6 GJ air filter

The work of a contaminated element negatively affects the force of filling the working chambers of the cylinders with air, which directly affects the efficiency of combustion of the working mixture and the optimal operation of the engine. Such a filter can pass impurities from the air into the cylinders, which leads to wear of the moving parts of the crank mechanism.

The result of poor performance of the air system can be an expensive repair of the power unit, which will cost many times more than one filter element.

Under optimal vehicle operating conditions, the Mazda 6 air filter reduces engine wear by 15-20%, and in difficult conditions by 200%!

Filter element location

Under the hood, the Mazda 6 air filter is located in a special housing into which air enters through the air duct. Then it passes through the filter element, enters the air flow meter and into the combustion chamber. 

The Mazda 6 filter housing in the engine compartment is installed on the left (between the battery and the engine, in the direction of the car). Near it is a fuse box.

Tips for self-replacement:

• To prevent dust from getting into the exhaust manifold, and then into the engine, do not take out the sharply used old filter.
• Close the filter box cover tightly. Check all latches. Then the air will not be pumped into the slots, passing by the filter itself.

To replace the Mazda 6 air filter, do the following:

1.  Place the vehicle on a level surface and place wheel chocks under the wheels.

2. Open the hood.

3.  If you stand in front of the car, the Mazda 6 filter housing will be in the right front of the engine compartment. Its upper part is attached to the filter with several metal fasteners. Unfasten the clasps by pulling them up.

4.  Disconnect the electrical connector.

5.  Remove the cover.

Note:

Some motorists believe that it is not at all necessary to completely remove the box: it is enough just to take it up with one hand, and with the other to get the old filter from the middle . But this option does not give full access to the lower part of the case and makes it difficult to rinse it well.

6.  Pull out the spent element.

Note:

Inspect the removed Mazda 6 filter on both sides and evaluate its condition. It should not have any cracks.

You can try to blow a part that is not too dirty with a compressor, clean it, and put it in place (you need to blow it from the clean side of the element). But if the air element is completely clogged with dust, debris, leaves or insects, then replacing the filter with a Mazda 6 is a must!

7.  Clean and flush the body cavity to remove debris, dust, and dirt. Wipe it dry.

8.  Replace the Mazda 6 air filter with a new one, and install it in place (ribbed side down).

9.  Place the tabs of the cover into the grooves at the back, and fasten the front latches back.

Benefits of timely filter replacement for Mazda 6:

• normal mode of supply of clean air;
• reduction in fuel consumption;
• optimal engine performance;
• reduction of wear of rubbing parts of the engine;
• reduced contamination of fuel injectors;
• saving money for future repairs.

Filter element selection

The manufacturer installs the original filter with the number  PE07-13-3A0A at the factory.

Its average price, for a given period of time, is about 1300 rubles. You can also order or buy a filter for Mazda 6 GJ and other companies that are suitable for engines. But, before buying, be sure to check with the seller whether your choice matches the classification of your car.

Analogues from other manufacturers:

• AMD AMDFA791 from 190 rubles; Profit 15212343 from 330 rubles;
• BIG Filter GB968 from 220 rubles; WIX WA9774 from 340 rubles;
• Fortech FA205 from 225 rubles; Bosch F 026 400 347 from 355 rubles;
• Goodwill AG439 from 225 rubles; LYNXauto LA1917 from 465 rubles;
• Interparts IPA665 from 255 rubles; Sakura A17200 from 530 rubles;
• NIPPARTS N1323065 from 285 rubles; Masuma MFAZ401 from 520 rubles.

Other Mazda 6 repair articles:

1.  Replacement of lamps Mazda 6 (GJ) 2012 - 2015

2.  Replacing the rear pads Mazda 6 (GJ) 2012 - 2019

3.  Replacing the front pads Mazda 6 (GJ) 2012 - 2019

4.  Replacing wipers on Mazda 6

5.  Oil change Mazda 6 (GJ)

6.  Oil change automatic transmission Mazda 6 (GJ)

Source:  carpedia.club